Voyage of the Paper Canoe Part 3

CHAPTER V.

THE AMERICAN PAPER BOAT AND ENGLISH CANOES.

THE PECULIAR CHARACTER OF THE PAPER BOAT.--THE HISTORY OF THE ADOPTION OF PAPER FOR BOATS.--A BOY'S INGENUITY.--THE PROCESS OF BUILDING PAPER BOATS DESCRIBED.--COLLEGE CLUBS ADOPTING THEM.--THE GREAT VICTORIES WON BY PAPER OVER WOODEN Sh.e.l.lS IN 1876.

Inquiries regarding the history and durability of paper boats occasionally reach me through the medium of the post-office. After all the uses to which paper has been put during the last twenty years, the public is yet hardly convinced that the flimsy material, paper, can successfully take the place of wood in the construction of light pleasure-boats, canoes, and racing sh.e.l.ls. Yet the idea has become an accomplished fact. The success of the victorious paper sh.e.l.ls of the Cornell College navy, which were enlisted in the struggles of two seasons at Saratoga, against no mean antagonists,--the college crews of the United States,--surely proves that in strength, stiffness, speed, and fineness of model, the paper boat is without a rival.

[Ill.u.s.tration: A FULL-RIGGED NAUTILUS CANOE.]

When used in its own peculiar sphere, the improved paper boat will be found to possess the following merits: less weight, greater strength, stiffness, durability, and speed than a wooden boat of the same size and model; and the moulded paper sh.e.l.l will retain the delicate lines so essential to speed, while the brittle wooden sh.e.l.l yields more or less to the warping influences of sun and moisture. A comparison of the strength of wood and paper for boats has been made by a writer in the Cornell Times, a journal published by the students of that celebrated New York college:

"Let us take a piece of wood and a piece of paper of the same thickness, and experiment with, use, and abuse them both to the same extent. Let the wood be of one-eighth of an inch in thickness--the usual thickness of sh.e.l.l-boats, and the paper heavy pasteboard, both one foot square. Holding them up by one side, strike them with a hammer, and observe the result. The wood will be cracked, to say the least; the pasteboard, whirled out of your hand, will only be dented, at most. Take hold and bend them: the wood bends to a certain degree, and then splits; the pasteboard, bent to the same degree, is not affected in the least. Take a knife and strike them: the wood is again split, the pasteboard only pierced. Place them on the water: the wood floats for an indefinite time; the pasteboard, after a time, soaks, and finally sinks, as was to be expected. But suppose we soak the pasteboard in marine glue before the experiment, then we find the pasteboard equally as impervious to the water as wood, and as buoyant, if of the same weight; but, to be of the same weight, it must be thinner than the wood, yet even then it stands the before-mentioned tests as well as when thicker; and it will be found to stand all tests much better than wood, even when it weighs considerably less.

"Now, enlarging our pieces, and moulding them into boats of the same weight, we find the following differences: Wood, being stiff and liable to split, can only be moulded into comparative form. Paper, since it can be rendered perfectly pliable, can be pressed into any shape desirable; hence, any wished-for fineness of lines can be given to the model, and the paper will a.s.sume the identical shape, after which it can be water-proofed, hardened, and polished. Paper neither swells, nor shrinks, nor cracks, hence it does not leak, is always ready for use, always serviceable. As to cost, there is very little difference between the two; the cost being within twenty-five dollars, more or less, the same for both. Those who use paper boats think them very near perfection; and surely those who have the most to do with boats ought to know, prejudice aside, which is the best."

An injury to a paper boat is easily repaired by a patch of strong paper and a coating of sh.e.l.lac put on with a hot iron. As the paper boat is a novelty with many people, a sketch of its early history may prove interesting to the reader. Mr. George A. Waters, the son of the senior member of the firm of E. Waters & Sons, of Troy, New York, was invited some years since to a masquerade party. The boy repaired to a toy shop to purchase a counterfeit face; but, thinking the price (eight dollars) was more than he could afford for a single evening's sport, he borrowed the mask for a model, from which he produced a duplicate as perfect as was the original. While engaged upon his novel work, an idea impressed itself upon his ingenious brain. "Cannot," he queried, "a paper sh.e.l.l be made upon the wooden model of a boat? And will not a sh.e.l.l thus produced, after being treated to a coat of varnish, float as well, and be lighter than a wooden boat?"

This was in March, 1867, while the youth was engaged in the manufacture of paper boxes. Having repaired a wooden sh.e.l.l-boat by covering the cracks with sheets of stout paper cemented to the wood, the result satisfied him; and he immediately applied his attention to the further development of his bright idea. a.s.sisted by his father, Mr. Elisha Waters, the enterprise was commenced "by taking a wooden sh.e.l.l, thirteen inches wide and thirty feet long, as a mould, and covering the entire surface of its bottom and sides with small sheets of strong Manila paper, glued together, and superposed on each other, so that the joints of one layer were covered by the middle of the sheet immediately above, until a sheet of paper had been formed one-sixteenth of an inch in thickness. The fabric thus constructed, after being carefully dried, was removed from the mould and fitted up with a suitable frame, consisting of a lower keelson, two inwales, the bulkhead; in short, all the usual parts of the frame of a wooden sh.e.l.l, except the timbers, or ribs, of which none were used--the extreme stiffness of the skin rendering them unnecessary. Its surface was then carefully water-proofed with suitable varnishes, and the work was completed. Trials proved that, rude as was this first attempt compared with the elegant craft now turned out from paper, it had marked merits, among which were, its remarkable stiffness, the symmetry of the hull with respect to its long axis, and the smoothness of the water-surface."

A gentleman, who possesses excellent judgment and long experience in all that relates to paper boats, furnishes me with the following valuable information, which I feel sure will interest the reader.

"The process of building the paper sh.e.l.l-boat is as follows: The dimensions of the boat having been determined upon, the first step is to construct a wooden model, or form, an exact fac-simile of the desired boat, on which to mould the paper skin. For this purpose the lines of the boat are carefully drawn out of the full size, and from the drawings thus made the model is prepared. It is built of layers of well-seasoned pine, securely fastened together to form one solid ma.s.s; which, after having been laid up of the general outline required, is carefully worked off, until its surface, which is made perfectly smooth, exactly conforms to the selected lines, and its beam, depth, and length are those of the given boat. During the process of its construction, suitable rabbets are cut to receive the lower keelson, the two inwales, and the bow and stern deadwoods, which, being put in position, are worked off so that their surfaces are flush with that of the model, and forming, as it were, an integral part of it. It being important that these parts should, in the completed boat, be firmly attached to the skin, their surface is, at this part of the process, covered with a suitable adhesive preparation.

"The model is now ready to be covered with paper. Two kinds are used: that made from the best Manila, and that prepared from pure unbleached linen stock; the sheets being the full length of the model, no matter what that may be. If Manila paper is used, the first sheet is dampened, laid smoothly on the model, and securely fastened in place by tacking it to certain rough strips attached to its upper face. Other sheets are now superposed on this and on each other, and suitably cemented together; the number depending upon the size of the boat and the stiffness required. If linen paper is used, but one sheet is employed, of such weight and dimensions that, when dry, it will give just the thickness of skin necessary. Should the surface of the model be concave in parts, as in the run of boats with square sterns for instance, the paper is made to conform to these surfaces by suitable convex moulds, which also hold the paper in place until, by drying, it has taken and will retain the desired form.

The model, with its enveloping coat of paper, is now removed to the dry-room. As the paper skin dries, all wrinkles disappear, and it gradually a.s.sumes the desired shape. Finally, when all moisture has been evaporated, it is taken from the mould an exact fac-simile of the model desired, exceedingly stiff, perfectly symmetrical, and seamless.

"The paper is now subjected to the water-proof process, and the skin, with its keelson, inwales, and deadwoods attached, is then placed in the carpenter's hands, where the frame is completed in the usual manner, as described for wooden boats. The paper decks being put on, it is then ready for the bra.s.s, iron, and varnish work. As the skins of these boats (racing-sh.e.l.ls) vary from one-sixteenth of an inch in the singles, to one-twelfth of an inch in the six-oared outriggers, the wooden frame becomes necessary to support and keep them in shape. In applying this invention to gigs, dingys, canoes, and skiffs, a somewhat different method is adopted. Since these boats are subjected to much hard service, and must be so constructed as to permit the occupant to move about in them as is usual in such craft, a light and strong frame of wood is prepared, composed of a suitable number of pairs of ribs, with stem and stern pieces cut from the natural crooks of hackmatack roots. These are firmly framed to two gunwales and a keelson, extending the length of the boat; the whole forming the skeleton shape of the desired model. The forms for these boats having been prepared, as already described for the racing-sh.e.l.ls, and the frame being let into this form, so that the outer surface of the ribs, stem and stern pieces will conform with its outer surface, the paper skin is next laid upon it. The skin, manufactured from new, unbleached linen stock, is carefully stretched in place, and when perfectly dry is from one-tenth to three-sixteenths of an inch thick. Removed from the model, it is water-proofed, the frame and fittings completed, and the boat varnished. In short, in this cla.s.s of boats, the shape, style, and finish are precisely that of wooden ones, of corresponding dimensions and cla.s.s, except that for the usual wooden sheathing is subst.i.tuted the paper skin as described.

"The advantages possessed by these boats over those of wood are:

"By the use of this material for the skins of racing-sh.e.l.ls, where experience has demonstrated the smooth bottom to be the best, under-water lines of any degree of fineness can be developed, which cannot successfully be produced in those of wood, even where the streaks are so reduced in thickness that strength, stiffness, and durability are either wholly sacrificed or greatly impaired. In the finer varieties of 'dug-outs'

equally fine lines can be obtained; but so delicate are such boats, if the sides are reduced to three-sixteenths of an inch or less in thickness, that it is found practically impossible to preserve their original forms for any length of time. Hence, so far as this point is concerned, it only remains for the builder to select those models which science, guided by experience, points out as the best.

"The paper skin, after being water-proofed, is finished with hard varnishes, and then presents a solid, perfectly smooth, and h.o.r.n.y surface to the action of the water, unbroken by _joint_, _lap_, or _seam_. This surface admits of being polished as smooth as a coach-panel or a mirror. Unlike wood, _it has no grain to be cracked or split, it never shrinks_, and, paper being one of the best of non-conductors, no ordinary degree of heat or cold affects its shape or hardness, and hence these boats are admirably adapted for use in all climates. As the skin absorbs no moisture, _these boats gain no weight by use_, and, having no moisture to give off when out of the water, they do not, like wooden boats, show the effect of exposure to the air by leaking. They are, therefore, in this respect always prepared for service.

"The strength and stiffness of the paper sh.e.l.ls are most remarkable. To demonstrate it, a single sh.e.l.l of twelve inch beam and twenty-eight feet long, fitted complete with its outriggers, the hull weighing twenty-two pounds, was placed on two trestles eight feet apart, in such a manner that the trestles were each the same distance from the centre of the c.o.c.kpit, which was thus entirely unsupported. A man weighing one hundred and forty pounds then seated himself in it, and remained in this position three minutes. The deflection caused by this strain, being accurately measured, was found to be one-sixteenth of an inch at a point midway between the supports. If this load, applied under such abnormal conditions, produced so little effect, we can safely a.s.sume that, when thus loaded and resting on the water, supported throughout her whole length, and the load far more equally distributed over the whole frame, there would be no deflection whatever.

"Lightness, when combined with a proper, stiffness and strength, being a very desirable quality, it is here that the paper boats far excel their wooden rivals. If two sh.e.l.ls are selected, the one of wood and the other with a paper skin and deck, as has been described, _of the same dimensions and equally stiff_, careful experiment proves that the wooden one will be _thirty per cent. the heaviest_. If those of the _same dimensions and equal weight_ are compared, the paper one will be found to exceed the wooden one in stiffness and in capacity to resist torsional strains in the same proportion. Frequent boasts are made that wooden sh.e.l.ls can be and are built much lighter than paper ones; and if the quality of lightness _alone_ is considered, this is true; yet when the practical test of _use_ is applied, such extremely light wooden boats have always proved, and will continue to prove, failures, as here this quality is only _one_ of a number which combine to make the boat serviceable. A wooden sh.e.l.l whose hull weighs twenty-two pounds, honest weight, is a very fragile, short-lived affair. A paper sh.e.l.l of the same dimensions, and of the same weight, will last as long, and do as much work, as a wooden one whose hull turns the beam at thirty pounds.

"An instance of their remarkable strength is shown in the following case. In the summer of 1870, a single sh.e.l.l, while being rowed at full speed, with the current, on one of our princ.i.p.al rivers, was run into the stone abutment of a bridge.

The bow struck squarely on the obstacle, and such was the momentum of the ma.s.s that the oarsman was thrown directly through the flaring bow of the c.o.c.kpit into the river. Witnesses of the accident who were familiar with wooden sh.e.l.ls declared that the boat was ruined; but, after a careful examination, only the bow-tip was found to be twisted in a spiral form, and the washboard broken at the point by the oarsman as he pa.s.sed between the sides. Two dollars covered the cost of repair. Had it been a wooden sh.e.l.l the shock would have crushed its stem and splintered the skin from the bow to the waist."

[Ill.u.s.tration: ROB ROY CANOE.]

Old and cautious seamen tried to dissuade me from contracting with the Messrs. Waters for the building of a stout paper canoe for my journey.

Harvard College had not adopted this "new-fangled notion" at that time, and Cornell had only begun to think of attempting to out-row other colleges at Saratoga by using paper boats. The Centennial year of the independence of the United States, 1876, settled all doubts as to the value of the result of the years of toil of the inventors of the paper boat. During the same year the incendiary completed his revengeful work by burning the paper-boat manufactory at Troy. The loss was a heavy one; but a few weeks later these unflinching men were able to record the following victories achieved that single season by their boats.

The races won by the paper boats were:

The Intercollegiate Champions.h.i.+p: Freshmen and University.

The International Champions.h.i.+p at Saratoga: Singles, Doubles, and Fours.

The National Champions.h.i.+p, N. A. of A. O.: Singles, Doubles, and Fours.

The World's Champions.h.i.+p at Centennial Exhibition: Singles, Doubles, and Fours.

The Professional Champions.h.i.+p of the United States.

And every other important race of the season, besides receiving the highest honors at the Centennial Exhibition. The right to make boats of paper in Canada and in the United States is exclusively held by the Messrs. Waters, and they are the only manufacturers of paper boats in the world.

It is not many years since Mr. Macgregor, of London, built the little Rob Roy canoe, and in it made the tour of interesting European waters.

His example was followed by an army of tourists, and it is now a common thing to meet canoe voyagers in miniature flotillas upon the watercourses of our own and foreign lands. Mr. W. Baden-Powell, also an Englishman, perfected the model of the Nautilus type of canoe, which possesses a great deal of sheer with fullness of bow, and is therefore a better boat for rough water than the Rob Roy. The New York Canoe Club, in 1874, had the Nautilus for their model. We still need a distinctive American type for our waters, more like the best Indian canoe than the European models here presented. These modern yacht-like canoes are really improved _kyaks_, and in their construction we are much indebted to the experience of the inhabitants of the Arctic Circle. Very few of the so-called Rob Roy canoes, built in the United States, resemble the original perfected boat of Mr. Macgregor--the father of modern canoe travelling. The ill.u.s.trations given of English canoes are from imported models, and are perfect of their type.

CHAPTER VI.

TROY TO PHILADELPHIA.

PAPER CANOE MARIA THERESA.--THE START.--THE DESCENT OF THE HUDSON RIVER.--CROSSING THE UPPER BAY OF NEW YORK.--Pa.s.sAGE OF THE KILLS.--RARITAN RIVER.--THE Ca.n.a.l ROUTE FROM NEW BRUNSWICK TO THE DELAWARE RIVER.--FROM BORDENTOWN TO PHILADELPHIA.

[Ill.u.s.tration: From Albany to New York City.

Route of Paper Canoe MARIA THERESA From Albany to New York City Via Hudson River Followed by N. H. Bishop in 1874 _Copyright, 1878 by Lee & Shepard_]

My canoe of the English "Nautilus" type was completed by the middle of October; and on the cold, drizzly morning of the 21st of the same month I embarked in my little fifty-eight pound craft from the landing of the paper-boat manufactory on the river Hudson, two miles above Troy. Mr.

George A. Waters put his own canoe into the water, and proposed to escort me a few miles down the river. If I had any misgivings as to the stability of my paper canoe upon entering her for the first time, they were quickly dispelled as I pa.s.sed the stately Club-house of the Laureates, which contained nearly forty sh.e.l.ls, _all_ of paper.

The dimensions of the Maria Theresa were: length, fourteen feet; beam, twenty-eight inches; depth, amids.h.i.+ps, nine inches; height of bow from horizontal line, twenty-three inches; height of stern, twenty inches.

The canoe was one-eighth of an inch in thickness, and weighed fifty-eight pounds. She was fitted with a pair of steel outriggers, which could be easily uns.h.i.+pped and stowed away. The oars[B] were of spruce, seven feet eight inches long, and weighed three pounds and a quarter each. The double paddle, which was seven feet six inches in length, weighed two pounds and a half. The mast and sail--which are of no service on such a miniature vessel, and were soon discarded--weighed six pounds. When I took on board at Philadelphia the canvas deck-cover and the rubber strap which secured it in position, and the outfit,--the cus.h.i.+on, sponge, provision-basket, and a fifteen-pound case of charts,--I found that, with my own weight included (one hundred and thirty pounds), the boat and her cargo, all told, provisioned for a long cruise, fell considerably short of the weight of three Saratoga trunks containing a very modest wardrobe for a lady's four weeks'

visit at a fas.h.i.+onable watering-place.

The rain ceased, the mists ascended, and the sunlight broke upon us as we swiftly descended upon the current of the Hudson to Albany. The city was reached in an hour and a half. Mr. Waters, pointing his canoe northward, wished me _bon voyage_, and returned to the scene of the triumphs of his patient labors, while I settled down to a steady row southward. At Albany, the capital of the state, which is said to be one hundred and fifty miles distant from New York city, there is a tidal rise and fall of one foot.

A feeling of buoyancy and independence came over me as I glided on the current of this n.o.ble stream, with the consciousness that I now possessed the right boat for my enterprise. It had been a dream of my youth to become acquainted with the charms of this most romantic river of the American continent. Its sources are in the clouds of the Adirondacks, among the cold peaks of the northern wilderness; its ending may be said to be in the briny waters of the Atlantic, for its channel-way has been sounded outside of the sandy beaches of New York harbor in the bosom of the restless ocean. The highest types of civilized life are nurtured upon its banks. n.o.ble edifices, which contain and preserve the works of genius and of mechanical art, rear their proud roofs from among these hills on the lofty sites of the picturesque Hudson. The wealth of the great city at its mouth, the metropolis of the young nation, has been lavished upon the soil of the river's borders to make it even more beautiful and more fruitful. What river in America, along the same length of coast-lines as from Troy to New York (one hundred and fifty-six miles), can rival in natural beauty and artificial applications of wealth the lovely Hudson? "The Hudson River," says its genial historian, Mr. Lossing, "from its birth among the mountains to its marriage with the ocean, measures a distance of full three hundred miles."

[Ill.u.s.tration: THE ABORIGINAL TYPE (KAYAK.)]

[Ill.u.s.tration: THE IMPROVED TYPE (MARIA THERESA CANOE.)]

Captain John Smith's friend, the Englishman Henry Hudson, while in the employ of the Dutch East India Company, in his vessel of ninety tons, the Half-Moon, being in search of a northwest pa.s.sage south of Virginia, cast anchor outside of Sandy Hook, September 3, 1609, and on the 11th pa.s.sed up through the Narrows into the present bay of New York. Under the firm conviction that he was on his way to the long-sought Cathay, a day later he entered the Hudson River, where now stands the proud metropolis of America. As the Half-Moon ascended the river the water lost its saltness, and by the time they were anch.o.r.ed where the city of Albany now stands all hopes of Cathay faded from the heart of the mariner. Englishmen called this river in honor of its discoverer, but the Dutch gave it the name of North River, after the Delaware had been discovered and named South River. Thus, while in 1609 Samuel Champlain was exploring the lake which bears his name, Hudson was ascending his river upon the southern water-shed. The historian tells us that these bold explorers penetrated the wilderness, one from the north and the other from the south, to within one hundred miles of each other.

The same historian (Dr. Lossing) says: "The most remote source of the extreme western branch of our n.o.ble river is Hendricks Spring, so named in honor of Hendricks Hudson. We found Hendricks Spring in the edge of a swamp, cold, shallow, about five feet in diameter,--shaded by trees, shrubbery, and vines, and fringed with the delicate brake and fern. Its waters, rising within half a mile of Long Lake, and upon the same summit-level, flow southward to the Atlantic more than three hundred miles; while those of the latter flow to the St. Lawrence, and reach the same Atlantic a thousand miles away to the far northeast."