Bevis Part 52

"Be you going a blacksmithing?"

"Yes--what will do for an anvil?"

"Iron quarter," said John. "There's an ould iron in the shed. Shall I take he whoam?" An iron quarter is a square iron weight weighing 28 pounds: it would make a useful anvil. It was agreed that he should do so, and they saw him put the old iron weight, rusty and long disused, up in the cart.

"If you wants anybody to blow the bellers," said he, "there's our Loo-- she'll blow for yer. Be you going to ride?"

"No," said Bevis; "we'll go across the fields."

Away they went by the meadow foot-path, a shorter route to the little town, and reached it before John and his cart. At the ironmonger's they examined a number of pipes, iron and bra.s.s tubes. The bra.s.s looked best, and tempted them, but on turning it round they fancied the join showed, and was not perfect, and of course that would not do. Nor did it look so strong as the iron, so they chose the iron, and bought five feet of a stout tube--the best in the shop--with a bore of 5-eighths; and afterwards a bra.s.s rod, which was to form the ramrod. Bra.s.s would not cause a spark in the barrel.

John called for these in due course, and left them at his cottage. The old rogue had his quart, and the promise of a s.h.i.+lling, if the hearth answered for the blacksmithing. In the evening, Mark, well primed as to what he was to ask, casually looked in at the blacksmith's down the hamlet. The blacksmith was not in the least surprised; they were both old frequenters; he was only surprised one or both had not been before.

Mark pulled some of the tools about, lifted the sledge which stood upright, and had left it's mark on the iron "scale" which lay on the ground an inch deep. Scale consists of minute particles which fly off red-hot iron when it is hammered--the sparks, in fact, which, when they go out, fall, and are found to be metal; like the meteors in the sky, the scale shooting from Vulcan's anvil, which go out and drop on the earth. Mark lifted the sledge, put it down, twisted up the vice, and untwisted it, while Jonas, the smith, stood blowing the bellows with his left hand, and patting the fire on the forge with his little spud of a shovel.

"Find anything you want," he said presently.

"I'll take this," said Mark. "There's sixpence."

He had chosen a bit of iron rod, short, and thicker than their ramrod.

Bevis had told him what to look for.

"All right, sir--anything else?"

"Well," said Mark, moving towards the door, "I don't know,"--then stopping with an admirable a.s.sumption of indifference. "Suppose you had to stop up one end of a pipe, how should you do it?"

"Make it white-hot," said the smith. "Bring it to me."

"Will white-hot shut tight?"

"Quite tight--it runs together when hit. Bring it to me. I say, where's the punt?" grinning. His white teeth gleamed between his open lips--a row of ivory set in a grimy face.

"The punt's at the bottom," said Mark, with a louring countenance.

"Nice boys," said the smith. "You're very nice boys. If you was mine--" He took up a slender ash plant that was lying on the bench, and made it ply and whistle in the air.

Mark tossed his chin, kicked the door open, and walked off.

"I say!--I say!" shouted the smith. "Bring it to me."

"Keep yourself to yourself," said Mark loftily.

Boys indeed! The smith swore, and it sounded in his broad deep chest like the noise of the draught up the furnace. He was angry with himself--he thought he had lost half-a-crown, at least, by just swis.h.i.+ng the stick up and down. If you want half-a-crown, you must control your feelings.

Mark told Bevis what the smith had said, and they went to work, and the same evening filed off the end of the rod Mark had bought. Bevis's plan was to file this till it almost fitted the tube, but not quite. Then he meant to make the tube red-hot--almost white--and insert the little block. He knew that heat would cause the tube to slightly enlarge, so that the block being cold could be driven in; then as the tube cooled it would shrink in and hold it tight, so that none of the gas of the powder could escape.

The block was to be driven in nearly half an inch below the rim; the rim was to be next made quite white-hot, and in that state hammered over till it met in the centre, and overlapped a little. Again made white-hot, the overlapping (like the paper of a paper tube doubled in) was to be hammered and solidly welded together. The breech would then be firmly closed, and there would not be the slightest chance of its blowing out. This was his own idea, and he explained it to Mark.

They had now to decide how long the barrel should be: they had bought rather more tube than they wanted. Five, or even four feet would be so long, the gun would be inconvenient to handle, though with a rest, and very heavy. In a barrel properly built up, the thickness gradually decreases from the breech to the muzzle, so that as the greatest weight is nearest the shoulder the gun balances. But this iron tube was the same thickness from one end to the other, and in consequence, when held up horizontally, it seemed very heavy at the farther extremity.

Yet they wanted a long barrel, else it would not be like a proper matchlock. Finally, they fixed on forty inches, which would be long, but not too long; with a barrel of three feet four inches they ought, they considered, to be able to kill at a great distance. Adding the stock, say fifteen inches, the total length would be four feet seven.

Next morning, taking their tools and a portable vice in a flag-basket, as they often did to the boat, they made a detour and went to John Young's cottage. On the door-step there sat a little girl without shoes or stockings; her ragged frock was open at her neck. At first, she looked about twelve years old, as the original impression of age is derived from height and size. In a minute or two she grew older, and was not less than fourteen. The rest of the family were in the fields at work, Loo had been left to wait upon them. Already she had a huge fire burning on the hearth, which was of brick; the floor too was brick.

With the door wide open they could hardly stand the heat till the flames had fallen. Bevis did not want so much flame; embers are best to make iron hot. Taking off their jackets they set to work, put the tube in the fire, arranged the anvil, screwed the vice to the deal table, which, though quite clean, was varnished with grease that had sunk into the wood, selected the hammer which they thought would suit, and told Loo to fetch them her father's hedging-gloves.

These are made of thick leather, and Mark thought he could hold the tube better with them, as it would be warm from one end to the other. The little block of iron, to form the breech, was filed smooth, so as to just _not_ fit the tube. When the tube was nearly white-hot, Mark put on the leather gloves, seized and placed the colder end on the anvil, standing the tube with the glowing end upwards.

Bevis took the iron block, or breech-piece, with his pincers, inserted it in the white-hot tube, and drove it down with a smart tap. Some scale fell off and dropped on Mark's s.h.i.+rt-sleeve, burning little holes through to his skin. He drew his breath between his teeth, so sudden and keen was the pain of the sparks, but did not flinch. Bevis hastily threw his jacket over Mark's arms, and then gave the block three more taps, till it was flush with the top of the tube.

By now the tube was cooling, the whiteness superseded by a red, which gradually became dull. Mark put the tube again in the fire, and Loo was sent to find a piece of sacking to protect his arm from the sparks. His face was not safe, but he had sloped his hat over it, and hold his head down. There were specks on his hat where the scale or sparks had burnt it. Loo returned with a sack, when Bevis, who had been thinking, discovered a way by which Mark might escape the sparks.

He pulled the table along till the vice fixed to it projected over the anvil. Next time Mark was to stand the tube upright just the same, but to put it in the vice, and tighten the vice quickly, so that he need not hold it. Bevis had a short punch to drive the block or breech-piece deeper into the tube. Loo, blowing at the embers, with her scorched face close to the fire, declared that the tube was ready. Mark drew it out, and in two seconds it was fixed in the vice, but with the colder end in contact with the anvil underneath. Bevis put his punch on the block and tapped it sharply till he had forced it half an inch beneath the rim.

He now adjusted it for the next heating himself, for he did not wish all the end of the tube to be so hot; he wanted the end itself almost white-hot, but not the rest. While it was heating they went out of doors to cool themselves, leaving Loo to blow steadily at the embers.

She watched their every motion as intent as a cat a mouse; she ran with her naked brown feet to fetch and carry; she smiled when Mark put on the leather gloves, for she would have held it with her hands, though it had been much hotter.

She would have put her arm on the anvil to receive a blow from the hammer; she would have gone down the well in the bucket if they had asked her. Her mind was full of this wonderful work--what could they be making? But her heart and soul was filled with these great big boys with their beautiful sparkling eyes and white arms, white as milk, and their wilful, imperious ways. How many times she had watched them from afar! To have them so near was almost too great a joy; she was like a slave under their feet; they regarded her less than the bellows in her hands.

Directly the tube was white-hot at the extremity, she called them. Mark set the tube up; Bevis carefully hammered the rim over, folding it down on the breech block. Another heating, and he hammered the yielding metal still closer together, welding the folds. A third heating, and he finished it, deftly levelling the projections. The breech was complete, and it was much better done than they had hoped. As it cooled the tube shrank on the block; the closed end of the tube shrank too, and the breech-piece was incorporated into the tube itself. Their barrel was indeed far safer at the breech than scores of the brittle guns turned out cheap in these days.

Loo, seeing them begin to put their tools in the flag-basket, asked, with tears in her eyes, if they were not going to do any more? They had been there nearly three hours, for each heating took some time, but it had not seemed ten minutes to her. Bevis handed the barrel to her, and told her to take great care of it; they would come for it at night. It was necessary to smuggle it up into the armoury at home, and that could not be done by day. She took it. Had he given it in charge of a file of soldiers it could not have been safer; she would watch it as a bird does her nest.

Just then John came in, partly for his luncheon, partly out of curiosity to see how they were getting on. "Picters you be!" said John.

Pictures they were--black and grimy, not so much from the iron as the sticks and logs, half burnt, which they had handled; they were, in fact, streaked and smudged with charcoal. Loo instantly ran for a bowl of water for them to wash, and held the towel ready. She watched them down the hill, and wished they had kicked her or pulled her hair. Other boys did; why did not they touch her? They might have done so. Next time she thought she would put her naked foot so that they would step on it; then if she cried out perhaps they would stroke her.

In the afternoon they took two spades up to the boat. The wind had fallen as usual, but they rowed to New Formosa. The Pinta being deep in the water and heavy with ballast, moved slowly, and it was a long row.

Mark cut two sticks, and these were driven into the face of the sand cliff, to show the outline of the proposed cave. It was to be five feet square, and as deep as they could dig it.

They cleared away the loose sand and earth at the foot in a few minutes, and began the excavation. The sand at the outside was soft and crumbled, but an inch deep it became harder, and the work was not anything like so easy as they had supposed. After pecking with the spades for a whole hour, each had only cut out a shallow hole.

"This is no good," said Mark; "we shall never do it like this."

"Pickaxes," said Bevis.

"Yes; and hatchets," said Mark. "We could chop this sand best."

"So we could," said Bevis. "There are some old hatchets in the shed; we'll sharpen them; they'll do."

They worked on another half-hour, and then desisted, and cutting some more sticks stuck them in the ground in a semicircle before the cliff, to mark where the palisade was to be fixed. The New Sea was still calm, and they had to row through the Mozambique all the way to the harbour.

In the evening they ground two old hatchets, which, being much worn and chipped, had been thrown aside, and then searched among the quant.i.ties of stored and seasoned wood and poles for a piece to make the stock of the matchlock. There was beech, oak, elm, ash, fir--all sorts of wood lying about in the shed and workshop. Finally, they selected a curved piece of ash, hard and well seasoned. The curve was nearly what was wanted, and being natural it would be much stronger. This was carried up into the armoury to be shaved and planed into shape.

At night they went for the barrel. Loo brought it, and Bevis, as he thought, accidentally stepped on her naked foot, crus.h.i.+ng it between his heel and the stones at the door. Loo cried out.

"O dear!" said he, "I am so sorry. Here--here's sixpence, and I'll send you some pears."

She put the sixpence in her mouth and bit it, and said nothing. She indented the silver with her teeth, disappointed because he had not stroked her, while she stood and watched them away.