American Woman's Home Part 4

[Ill.u.s.tration: Fig. 30.]

The writer has examined the methods most employed at the present time, which are all modifications of the two modes here described. One is that of Robinson, patented by a Boston company, which is a modification of the mining mode. It consists of the two ventilating tubes, such as are employed in mines, united in one shaft with a roof to keep out rain, and a valve to regulate the entrance and exit of air, as ill.u.s.trated in Fig. 30. This method works well in certain circ.u.mstances, but fails so often as to prove very unreliable. Another mode is that of Ruttan, which is effected by heating air. This also has certain advantages and disadvantages. But the mode adopted for the preceding cottage plan is free from the difficulties of both the above methods, while it will surely ventilate every room in the house, both by day and night, and at all seasons, without any risk to health, and requiring no attention or care from the family.

By means of a very small amount of fuel in the kitchen stove, to be described hereafter, the whole house can be ventilated, and all the cooking done both in warm and cold weather. This stove will also warm the whole house, in the Northern States, eight or nine months in the year. Two Franklin stoves, in addition, will warm the whole house during the three or four remaining coldest months.

In a warm climate or season, by means of the non-conducting castings, the stove will ventilate the house and do all the cooking, without imparting heat or smells to any part of the house except the stove-closet.

At the close of this volume, drawings, prepared by Mr. Lewis Leeds, are given, more fully to ill.u.s.trate this mode of warming and ventilation, and in so plain and simple a form that any intelligent woman who has read this work can see that the plan is properly executed, even with workmen so entirely ignorant on this important subject as are most house-builders, especially in the newer territories. In the same article, directions are given as to the best modes of ventilating houses that are already built without any arrangements for ventilation.

V.

THE CONSTRUCTION AND CARE OF STOVES, FURNACES, AND CHIMNEYS.

If all American housekeepers could be taught how to select and manage the most economical and convenient apparatus for cooking and for warming a house, many millions now wasted by ignorance and neglect would be saved. Every woman should be taught the scientific principles in regard to heat, and then their application to practical purposes, for her own benefit, and also to enable her to train her children and servants in this important duty of home life on which health and comfort so much depend.

The laws that regulate the generation, diffusion, and preservation of heat as yet are a sealed mystery to thousands of young women who imagine they are completing a suitable education in courses of instruction from which most that is practical in future domestic life is wholly excluded. We therefore give a brief outline of some of the leading scientific principles which every housekeeper should understand and employ, in order to perform successfully one of her most important duties.

Concerning the essential nature of heat, and its intimate relations with the other great natural forces, light, electricity, etc., we shall not attempt to treat, but shall, for practical purposes, a.s.sume it to be a separate and independent force. Heat or caloric, then, has certain powers or principles. Let us consider them:

First, we find _Conduction_, by which heat pa.s.ses from one particle to another next to it; as when one end of a poker is warmed by placing the other end in the fire. The bodies which allow this power free course are called conductors, and those which do not are named non-conductors, Metals are good conductors; feathers, wool, and furs are poor conductors; and water, air, and gases are non-conductors.

Another principle of heat is _Convection_, by which water, air, and gases are warmed. This is, literally, the process of _conveying_ heat from one portion of a fluid body to another by currents resulting from changes of temperature. It is secured by bringing one portion of a liquid or gas into contact with a heated surface, whereby it becomes lighter and expanded in volume. In consequence, the cooler and heavier particles above pressing downward, the lighter ones rise upward, when the former, being heated, rise in their turn, and give place to others again descending from above. Thus a constant motion of currents and interchange of particles is produced until, as in a vessel of water, the whole body comes to an equal temperature. Air is heated in the same way.

In case of a hot stove, the air that touches it is heated, becomes lighter, and rises, giving place to cooler and heavier particles, which, when heated, also ascend. It is owing to this process that the air of a room is warmest at the top and coolest at the bottom. It is owing to this principle, also, that water and air can not be heated by fire from above. For the particles of these bodies, being non-conductors, do not impart heat to each other; and when the warmest are at the top, they can not take the place of cooler and heavier ones below.

Another principle of heat (which it shares with light) is _Radiation_, by which all things send out heat to surrounding cooler bodies. Some bodies will absorb radiated heat, others will reflect it, and others allow it to pa.s.s through them without either absorbing or reflecting Thus, black and rough substances absorb heat, (or light,) colored and smooth articles reflect it, while air allows it to pa.s.s through without either absorbing or reflecting. It is owing to this, that rough and black vessels boil water sooner than smooth and light-colored ones.

Another principle is _Reflection_, by which heat radiated to a surface is turned back from it when not absorbed or allowed to pa.s.s through; just as a ball rebounds from a wall; just as sound is thrown back from a hill, making echo; just as rays of light are reflected from a mirror. And, as with light, the rays of heat are always reflected from a surface in an angle exactly corresponding to the direction in which it strikes that surface. Thus, if heated are comes to an object perpendicularly--that is, at right angles, it will be reflected back in the same line. If it strikes obliquely, it is reflected obliquely, at an angle with the surface precisely the same as the angle with which it first struck. And, of course, if it moves toward the surface and comes upon it in a line having so small an angle with it as to be almost parallel with it, the heated air is spread wide and diffused through a larger s.p.a.ce than when the angles are greater and the width of reflection less.

[Ill.u.s.tration: Fig. 31.]

[Ill.u.s.tration: Fig. 32.]

[Ill.u.s.tration: Fig. 33.]

The simplest mode of warming a house and cooking food is by radiated heat from fires; but this is the most wasteful method, as respects time, labor, and expense. The most convenient, economical, and labor-saving mode of employing heat is by convection, as applied in stoves and furnaces. But for want of proper care and scientific knowledge this method has proved very destructive to health. When warming and cooking were done by open fires, houses were well supplied with pure air, as is rarely the case in rooms heated by stoves. For such is the prevailing ignorance on this subject that, as long as stoves save labor and warm the air, the great majority of people, especially among the poor, will use them in ways that involve debilitated const.i.tutions and frequent disease.

The most common modes of cooking, where open fires are relinquished, are by the range and the cooking-stove. The range is inferior to the stove in these respects: it is less economical, demanding much more fuel; it endangers the dress of the cook while standing near for various operations; it requires more stooping than the stove while cooking; it will not keep a fire all night, as do the best stoves; it will not burn wood and coal equally well; and lastly, if it warms the kitchen sufficiently in winter, it is too warm for summer. Some prefer it because the fumes of cooking can be carried off; but stoves properly arranged accomplish this equally well.

After extensive inquiry and many personal experiments, the author has found a cooking-stove constructed on true scientific principles, which unites convenience, comfort, and economy in a remarkable manner. Of this stove, drawings and descriptions will now be given, as the best mode of ill.u.s.trating the practical applications of these principles to the art of cooking, and to show how much American women have suffered and how much they have been imposed upon for want of proper knowledge in this branch of their profession. And every woman can understand what follows with much less effort than young girls at high-schools give to the first problems of Geometry--for which they will never have any practical use, while attention to this problem of home affairs will cultivate the intellect quite as much as the abstract reasonings of Algebra and Geometry.,

[Ill.u.s.tration: Fig. 34.]

Fig. 34 represents a portion of the interior of this cooking-stove.

First, notice the fire-box, which has corrugated (literally, wrinkled) sides, by which s.p.a.ce is economized, so that as much heating surface is secured as if they were one third larger; as the heat radiates from every part of the undulating surface, which is one third greater in superficial extent than if it were plane. The shape of the fire-box also secures more heat by having oblique sides--which radiate more effectively into the oven beneath than if they were perpendicular, as ill.u.s.trated below--while also it is sunk into the oven, so as to radiate from three instead of from two sides, as in most other stoves, the front of whose fire-boxes with their grates are built so as to be the front of the stove itself.

[Ill.u.s.tration: Fig 35. Model Stove]

[Ill.u.s.tration: Fig 36. Ordinary Stove]

The oven is the s.p.a.ce under and around the back and front sides of the fire-box. The oven-bottom is not introduced in the diagram, but it is a horizontal plate between the fire-box and what is represented as the "flue-plate," which separates the oven from the bottom of the stove.

The top of the oven is the horizontal corrugated plate pa.s.sing from the rear edge of the fire-box to the back flues. These are three in number--the back centre-flue, which is closed to the heat and smoke coming over the oven from the fire-box by a damper--and the two back corner-flues. Down these two corner-flues pa.s.ses the current of hot air and smoke, having first drawn across the corrugated oven-top. The arrows show its descent through these flues, from which it obliquely strikes and pa.s.ses over the flue-plate, then under it, and then out through the centre back-flue, which is open at the bottom, up into the smoke-pipe.

The flue-plate is placed obliquely, to acc.u.mulate heat by forcing and compression; for the back s.p.a.ce where the smoke enters from the corner-flues is largest, and decreases toward the front, so that the hot current is compressed in a narrow s.p.a.ce, between the oven-bottom and the flue-plate at the place where the bent arrows are seen. Here again it enters a wider s.p.a.ce, under the flue-plate, and proceeds to another narrow one, between the flue-plate and the bottom of the stove, and thus is compressed and retained longer than if not impeded by these various contrivances. The heat and smoke also strike the plate obliquely, and thus, by reflection from its surface, impart more heat than if the pa.s.sage was a horizontal one.

The external radiation is regulated by the use of nonconducting plaster applied to the flue-plate and to the sides of the corner-flues, so that the heat is prevented from radiating in any direction except toward the oven. The doors, sides, and bottom of the stove are lined with tin casings, which hold a stratum of air, also a non-conductor.

These are so arranged as to be removed whenever the weather becomes cold, so that the heat may then radiate into the kitchen. The outer edges of the oven are also similarly protected from loss of heat by tin casings and air-s.p.a.ces, and the oven-doors opening at the front of the store are provided with the same economical savers of heat.

High tin covers placed on the top prevent the heat from radiating above the stove. These are exceedingly useful, as the s.p.a.ce under them is well heated and arranged for baking, for heating irons, and many other incidental necessities. Cake and pies can be baked on the top, while the oven is used for bread or for meats. When all the casings and covers are on, almost all the heat is confined within the stove, and whenever heat for the room is wanted, opening the front oven-doors turns it out into the kitchen.

Another contrivance is that of ventilating-holes in the front doors, through which fresh air is brought into the oven. This secures several purposes: it carries off the fumes of cooking meats, and prevents the mixing of flavors when different articles are cooked in the oven; it drives the heat that acc.u.mulates between the fire-box and front doors down around the oven, and equalizes its heat, so that articles need not be moved while baking; and lastly, as the air pa.s.ses through the holes of the fire-box, it causes the burning of gases in the smoke, and thus increases heat. When wood or bituminous coal is used, perforated metal linings are put in the fire-box, and the result is the burning of smoke and gases that otherwise would pa.s.s into the chimney. This is a great discovery in the economy of fuel, which can be applied in many ways.

Heretofore, most cooking-stoves have had dumping-grates, which are inconvenient from the dust produced, are uneconomical in the use of fuel, and disadvantageous from too many or too loose joints. But recently this stove has been provided with a dumping-grate which also will sift ashes, and can be cleaned without dust and the other objectionable features of dumping-grates. A further account of this stove, and the mode of purchasing and using it, will be given at the close of the book.

Those who are taught to manage the stove properly keep the fire going all night, and equally well with wood or coal, thus saving the expense of kindling and the trouble of starting a new fire. When the fuel is of good quality, all that is needed in the morning is to draw the back-damper, snake the grate, and add more fuel.

Another remarkable feature of this store is the extension-top, on which is placed a water reservoir, constantly heated by the smoke as it pa.s.ses from the stove, through one or two uniting pa.s.sages, to the smoke-pipe. Under this is placed a closet for warming and keeping hot the dishes, vegetables, meats, etc., while preparing for dinner. It is also very useful in drying fruit; and when large baking is required, a small appended pot for charcoal turns it into a fine large oven, that bakes as nicely as a brick oven.

Another useful appendage is a common tin oven, in which roasting can be done in front of the stove, the oven-doors being removed for the purpose. The roast will be done as perfectly as by an open fire.

This stove is furnished with pipes for heating water, like the water-back of ranges, and these can be taken or left out at pleasure.

So also the top covers, the baking-stool and pot, and the summer-back, bottom, and side-casings can be used or omitted as preferred.

[Ill.u.s.tration Fig 37]

Fig. 37 exhibits the stove completed, with all its appendages, as they might be employed in cooking for a large number.

Its capacity, convenience, and economy as a stove may be estimated by the following fact: With proper management of dampers, one ordinary-sized coal-hod of anthracite coal will, for twenty-four hours, keep the stove running, keep seventeen gallons of water hot at all hours, bake pies and puddings in the warm closet, heat flat-irons under the back cover, boil tea-kettle and one pot under the front cover, bake bread in the oven, and cook a turkey in the tin roaster in front.

The author has numerous friends, who, after trying the best ranges, have dismissed them for this stove, and in two or three years cleared the whole expense by the saving of fuel.

The remarkable durability of this stove is another economic feature.

For in addition to its fine castings and nice-fitting workmans.h.i.+p, all the parts liable to burn out are so protected by linings, and other contrivances easily renewed, that the stove itself may pa.s.s from one generation to another, as do ordinary chimneys. The writer has visited in families where this stove had been in constant use for eighteen and twenty years, and was still as good as new. In most other families the stoves are broken, burnt-out, or thrown aside for improved patterns every four, five, or six years, and sometimes, to the knowledge of the writer, still oftener.

Another excellent point is that, although it is so complicated in its various contrivances as to demand intelligent management in order to secure all its advantages, it also can be used satisfactorily even when the mistress and maid are equally careless and ignorant of its distinctive merits. To such it offers all the advantages of ordinary good stoves, and is extensively used by those who take no pains to understand and apply its peculiar advantages.

But the writer has managed the stove herself in all the details of cooking, and is confident that any housekeeper of common sense, who is instructed properly, and who also aims to have her kitchen affairs managed with strict economy, can easily train any servant who is willing to learn, so as to gain the full advantages offered. And even without any instructions at all, except the printed directions sent with the stove, an intelligent woman can, by due attention, though not without, both manage it, and teach her children and servants to do likewise.

And whenever this stove has failed to give the highest satisfaction, it has been, either because the housekeeper was not apprized of its peculiarities, or because she did not give sufficient attention to the matter, or was not able or willing to superintend and direct its management.

The consequence has been that, in families where this stove has been understood and managed aright, it has saved nearly one half of the fuel that would be used in ordinary stoves, constructed with the usual disregard of scientific and economic laws. And it is because we know this particular stove to be convenient, reliable, and economically efficient beyond ordinary experience, in the important housekeeping element of kitchen labor, that we devote to it so much s.p.a.ce and pains to describe its advantageous points.

CHIMNEYS.

One of the most serious evils in domestic life is often found in chimneys that will not properly draw the smoke of a fire or stove.

Although chimneys have been building for a thousand years, the artisans of the present day seem strangely ignorant of the true method of constructing them so as always to carry smoke upward instead of downward. It is rarely the case that a large house is built in which there is not some flue or chimney which "will not draw." One of the reasons why the stove described as excelling all others is sometimes cast aside for a poorer one is, that it requires a properly constructed chimney, and mult.i.tudes of women do not know how to secure it. The writer in early life shed many a bitter tear, drawn forth by smoke from an ill-constructed kitchen-chimney, and thousands all over the land can report the same experience.

The following are some of the causes and the remedies for this evil.

The most common cause of poor chimney draughts is too large an opening for the fireplace, either too wide or too high in front, or having too large a throat for the smoke. In a lower story, the fireplace should not be larger than thirty inches wide, twenty-five inches high, and fifteen deep. In the story above, it should be eighteen inches square and fifteen inches deep.

Another cause is too short a flue, and the remedy is to lengthen it.