Marvels of Modern Science Part 4

Some of the large concerns both in Europe and America at times employ from one hundred to two hundred hands and even more to ill.u.s.trate some of the productions. They send their photographers and actors all over the world for settings. Most of the business, however, is done near home. With trapping and other paraphernalia a stage setting can be effected to simulate almost any scene.

Almost anything under the sun can be enacted in a moving picture studio, from the drowning of a cat to the hanging of a man; a horse race or fire alarm is not outside the possible and the aviator has been depicted "flying" high in the heavens.

The places where the pictures are prepared must be adapted for the purpose. They are called studios and have gla.s.s roofs and in most of them a good section of the walls are also gla.s.s. The floor s.p.a.ce is divided into sections for the setting or staging of different productions, therefore several representations can take place at the same time before the eyes of the cameras. There are "properties" of all kinds from the ragged garments of the beggar to kingly ermine and queenly silks. Paste diamonds sparkle in necklaces, crowns and tiaras, seeming to rival the scintillations of the Kohinoor.

At the first, objections were made to moving pictures on the ground that in many cases they had a tendency to cater to the lower instincts, that subjects were ill.u.s.trated which were repugnant to the finer feelings and appealed to the gross and the sensual. Burglaries, murders and wild western scenes in which the villain-heroes triumphed were often shown and no doubt these had somewhat of a pernicious influence on susceptible youth. But all such pictures have for the most part been eliminated and there is a strict taboo on anything with a degrading influence or partaking of the brutal. Prize fights are often barred.

In many large cities there is a board of censors.h.i.+p to which the different manufacturing firms must submit duplicates. This board has to pa.s.s on all the films before they are released and if the pictures are in any way contrary to morals or decency or are in any respect unfit to be displayed before the public, they cannot be put in circulation. Thus are the people protected and especially the youth who should be permitted to see nothing that is not elevating or not of a nature to inspire them with high and n.o.ble thoughts and with ambitions to make the world better and brighter.

Let us hope that the future mission of the moving picture will be along educational and moral lines tending to uplift and enn.o.ble our boys and girls so that they may develop into a manhood and womanhood worthy the history and best traditions of our country.

The Wizard of Menlo Park has just succeeded after two years of hard application to the experiment in giving us the talking picture, a real genuine talking picture, wholly independent of the old device of having the actors talk behind the screen when the films were projected. By a combination of the phonograph and the moving picture machine working in perfect synchronism the result is obtained. Wires are attached to the mechanism of both the machines, the one behind the screen and the one in front, in such a way that the two are operated simultaneously so that when a film is projected a corresponding record on the phonograph acts in perfect unison supplying the voice suitable to the moving action. Men and women pa.s.s along the canvas, act, talk, laugh, cry and "have their being" just as in real life. Of course, they are immaterial, merely the reflection of films, but the one hundred thousandth of an inch thick, yet they give forth oral sounds as creatures of flesh and blood. In fact every sound is produced harmoniously with the action on the screen. An iron ball is dropped and you hear its thud upon the floor, a plate is cracked and you can hear the cracking just the same as if the material plate were broken in your presence. An immaterial piano appears upon the screen and a fleshless performer discourses airs as real as those heard on Broadway.

Melba and Tettrazini and Caruso and Bonci appear before you and warble their nightingale notes, as if behind the footlights with a galaxy of beauty, wealth and fas.h.i.+on before them for an audience. True it is not even their astral bodies you are looking at, only their pictured representations, but the magic of their voices is there all the same and there is such an atmosphere of realism about the representations that you can scarcely believe the actors are not present in _propriae personae_.

Mr. Edison had much study and labor of experiment in bringing his device to a successful issue. The greatest obstacle he had to overcome was in getting a phonograph that could "hear" far enough. At the beginning of the experiments the actor had to talk directly into the horn, which made the right kind of pictures impossible to get. Bit by bit, however, a machine was perfected which could "hear" so well that the actor could move at his pleasure within a radius of twenty feet.

That is the machine that is being used now. This new combination of the moving picture machine and the phonograph Edison has named the _kinetophone_. By it he has made possible the bringing of grand opera into the hamlets of the West, and through it also our leading statesmen may address audiences on the mining camps and the wilds of the prairies where their feet have never trodden.

CHAPTER V

SKY-Sc.r.a.pERS AND HOW THEY ARE BUILT

Evolution of the Sky-sc.r.a.per--Construction--New York's Giant Buildings--Dimensions.

The sky-sc.r.a.per is an architectural triumph, but at the same time it is very much of a commercial enterprise, and it is indigenous, native-born to American soil. It had its inception here, particularly in New York and Chicago. The tallest buildings in the world are in New York. The most notable of these, the Metropolitan Life Insurance Building with fifty stories towering up to a height of seven hundred feet and three inches, has been the crowning achievement of architectural art, the highest building yet erected by man.

How is it possible to erect such building--how is it possible to erect a sky-sc.r.a.per at all? A partial answer may be given in one word--_steel_.

Generally speaking the method of building all these huge structures is much the same. Ma.s.sive piers or pillars are erected, inside which are usually strong steel columns; crosswise from column to column great girders are placed forming a base for the floor, and then upon the first pillars are raised other steel columns slightly decreased in size, upon which girders are again fixed for the next floor; and so on this process is continued floor after floor. There seems no reason why buildings should not be reared like this for even a hundred stories, provided the foundations are laid deep enough and broad enough.

The walls are not really the support of the buildings. The essential elements are the columns and girders of steel forming the skeleton framework of the whole. The masonry may a.s.sist, but the piers and girders carry the princ.i.p.al weight. If, therefore, everything depends upon these piers, which are often of steel and masonry combined, the immense importance will be seen of basing them upon adequate foundations. And thus it comes about that to build high we must dig deep, which fact may be construed as an aphorism to fit more subjects than the building of sky-sc.r.a.pers.

To attempt to build a sky-sc.r.a.per without a suitable foundation would be tantamount to endeavoring to build a house on a marsh without draining the marsh,--it would count failure at the very beginning. The formation depends on the height, the calculated weight the frame work will carry, the amount of air pressure, the vibrations from the running of internal machines and several other details of less importance than those mentioned, but of deep consequence in the aggregate.

Instead of being carried on thick walls spread over a considerable area of ground, the sky-sc.r.a.pers are carried wholly on steel columns.

This concentrates many hundred tons of load and develops pressure which would crush the masonry and cause the structures to penetrate soft earth almost as a stone sinks in water.

In the first place the weight of the proposed building and contents is estimated, then the character of the soil determined to a depth of one hundred feet if necessary. In New York the soil is treacherous and difficult, there are underground rivers in places and large deposits of sand so that to get down to rock bottom or pan is often a very hard undertaking.

Generally speaking the excavations are made to about a depth of thirty feet. A layer of concrete a foot or two thick is spread over the bottom of the pit and on it are bedded rows of steel beams set close together.

Across the middle of these beams deep steel girders are placed on which the columns are erected. The heavy weight is thus spread out by the beams, girders and concrete so as to cause a reduced uniform pressure on the soil. Cement is filled in between the beams and girders and packed around them to seal them thoroughly against moisture; then clean earth or sand is rammed in up to the column bases and covered with the concrete of the cellar floor.

In some cases the foundation loads are so numerous that nothing short of masonry piers on solid rock will safely sustain them. To accomplish this very strong airtight steel or wooden boxes with flat tops and no bottoms are set on the pier sites at ground water level and pumped full of compressed air while men enter them and excavating the soil, undermine them, so they sink, until they land on the rock and are filled solid with concrete to form the bases of the foundation piers.

On the average the formation should have a resisting power of two tons to the square foot, dead load. By dead load is meant the weight of the steelwork, floors and walls, as distinguished from the office furniture and occupants which come under the head of living load. Some engineers take into consideration the pressure of both dead and live loads gauging the strength of the foundation, but the dead load pressure of 2 tons to the square foot will do for the reckoning, for as a live load only exerts a pressure of 60 lbs. to the square foot it may be included in the former.

The columns carry the entire weights including dead and live loads and the wind pressure, into the footings, these again distributing the loads on the soil. The aim is to have an equal pressure per square foot of soil at the same time, for all footings, thus insuring an even settlement. The skeleton construction now almost wholly consists of wrought steel. At first cast-iron and wrought-iron were used but it was found they corroded too quickly.

There are two cla.s.ses of steel construction, the cage and the skeleton.

In the cage construction the frame is strengthened for wind stresses and the walls act as curtains. In the skeleton, the frame carries only the vertical loads and depends upon the walls for its wind bracing.

It has been found that the wind pressure is about 30 lbs. for every square foot of exposed surface.

The steel columns reach from the foundation to the top, riveted together by plates and may be extended to an indefinite height. In fact there is no engineering limit to the height.

The outside walls of the sky-sc.r.a.per vary in thickness with the height of the building and also vary in accordance with the particular kind of construction, whether cage or skeleton. If of the cage variety, the walls, as has been said, act as curtains and consequently they are thinner than in the skeleton type of construction. In the latter case the walls have to resist the wind pressure unsupported by the steel frame and therefore they must be of a sufficient width. Brick and terra-cotta blocks are used for construction generally.

Terra-cotta blocks are also much used in the flooring, and for this purpose have several advantages over other materials; they are absolutely fire-proof, they weigh less per cubic foot than any other kind of fire-proof flooring and they are almost sound-proof. They do equally well for flat and arched floors.

It is of the utmost importance that the sky-sc.r.a.per be absolutely fire-proof from bottom to top. These great buzzing hives of industry house at one time several thousand human beings and a panic would entail a fearful calamity, and, moreover, their height places the upper stories beyond reach of a water-tower and the pumping engines of the street.

The sky-sc.r.a.pers of to-day are as fireproof as human ingenuity and skill can make them, and this is saying much; in fact, it means that they cannot burn. Of course fires can break out in rooms and apartments in the manufacturing of chemicals or testing experiments, etc., but these are easily confined to narrow limits and readily extinguished with the apparatus at hand. Steel columns will not burn, but if exposed to heat of sufficient degree they will warp and bend and probably collapse, therefore they should be protected by heat resisting agents.

Nothing can be better than terra-cotta and concrete for this purpose.

When terra-cotta blocks are used they should be at least 2 inches thick with an air s.p.a.ce running through them. Columns are also fire-proofed by wrapping expanded metal or other metal lathing around them and plastering.

Then a furring system is put on and another layer of metal, lathing and plastering. This if well done is probably safer than the layer of hollow tile.

The floor beams should be entirely covered with terra-cotta blocks or concrete, so that no part of them is left exposed. As most office tr.i.m.m.i.n.gs are of wood care should be taken that all electric wires are well insulated. Faulty installation of dynamos, motors and other apparatus is frequently the cause of office fires.

The lighting of a sky-sc.r.a.per is a most elaborate arrangement. Some of them use as many lights as would well supply a good sized town. The Singer Building in New York has 15,000 incandescent lamps and it is safe to say the Metropolitan Life Insurance Building has more than twice this number as the floor area of the latter is 2-1/2 times as great. The engines and dynamos are in the bas.e.m.e.nt and so fixed that their vibrations do not affect the building. As s.p.a.ce is always limited in the bas.e.m.e.nts of sky-sc.r.a.pers direct connected engines and dynamos are generally installed instead of belt connected and the boilers operated under a high steam pressure. Besides delivering steam to the engines the boilers also supply it to a variety of auxiliary pumps, as boiler-feed, fire-pump, blow-off, tank-pump and pump for forcing water through the building.

The heating arrangement of such a vast area as is covered by the floor s.p.a.ce of a sky-sc.r.a.per has been a very difficult problem but it has been solved so that the occupant of the twentieth story can receive an equal degree of heat with the one on the ground floor. Both hot water and steam are utilized. Hot water heating, however, is preferable to steam, as it gives a much steadier heat. The radiators arc proportioned to give an average temperature of 65 degrees F. in each room during the winter months. There are automatic regulating devices attached to the radiators, so if the temperature rises above or falls below a certain point the steam or hot water is automatically turned on or off. Some buildings are heated by the exhaust steam from the engines but most have boilers solely for the purpose.

The sanitary system is another important feature. The supplying of water for wash-stands, the dispositions of wastes and the flus.h.i.+ng of lavatories tax all the skill of the mechanical engineer. Several of these mighty buildings call for upwards of a thousand lavatories.

In considering the sky-sc.r.a.per we should not forget the role played by the electric elevator. Without it these buildings would be practically useless, as far as the upper stories are concerned. The labor of stair climbing would leave them untenanted. No one would be willing to climb ten, twenty or thirty flights and tackle a day's work after the exertion of doing so. To climb to the fiftieth story in such a manner would be well-nigh impossible or only possible by relays, and after one would arrive at the top he would be so physically exhausted that both mental and manual endeavor would be out of the question.

Therefore the elevator is as necessary to the skysc.r.a.per as are doors and windows. Indeed were it not for the introduction of the elevator the business sections of our large cities would still consist of the five and six story structures of our father's time instead of the towering edifices which now lift their heads among the clouds.

Regarded less than half a century ago as an unnecessary luxury the elevator to-day is an imperative necessity. Sky-sc.r.a.pers are equipped with both express and local elevators. The express elevators do not stop until about the tenth floor is reached. They run at a speed of about ten feet per second. There are two types of elevators in general use, one lifting the car by cables from the top, and the other with a hydraulic plunger acting directly upon the bottom of the car. The former are operated either by electric motors or hydraulic cylinders and the latter by hydraulic rams, the cylinders extending the full height of the building into the ground.

America is pre-eminently the land of the sky-sc.r.a.per, but England and France to a degree are following along the same lines, though nothing as yet has been erected on the other side of the water to equal the towering triumphs of architectural art on this side. In no country in the world is s.p.a.ce at such a premium as in New York City, therefore, New York _per se_ may be regarded as the true home of the tall building, although Chicago is not very much behind the Metropolis in this respect.

As figures are more eloquent than words in description the following data of the two giant structures of the Western World may be interesting.

The Singer Building at the corner of Broadway and Liberty Street, New York City, has a total height from the bas.e.m.e.nt floor to the top of the flagstaff of 742 feet; the height from street to roof is 612 feet, 1 inch. There are 41 stories. The weight of the steel in the entire building is 9,200 tons. It has 16 elevators, 5 steam engines, 5 dynamos, 5 boilers and 28 steam pumps. The length of the steam and water piping is 5 miles. The cubical contents of the building comprise 66,950,000 cubic feet, there are 411,000 square feet of floor area or about 9-1/2 acres. The weight of the tower is 18,300 tons. Little danger from a collapse will be apprehended when it is learned that the columns are securely bolted and caissons which have been sunk to rock-bed 80 feet below the curb.

The other campanile which has excited the wonder and admiration of the world is the colossal pile known as the Metropolitan Building. This occupies the entire square or block as we call it from 23rd St. to 24th St. and from Madison to Fourth Avenue. It is 700 feet and 3 inches above the sidewalk and has 50 stories. The main building which has a frontage of 200 feet by 425 feet is ten stories in height. It is built in the early Italian renaissance style the materials being steel and marble. The Campanile is carried up in the same style and is also of marble. It stands on a base measuring 75 by 83 feet and the architectural treatment is chaste, though severe, but eminently agreeable to the stupendous proportions of the structure. The tower is quite different from that of the Singer Building. It has twelve wall and eight interior columns connected at every fourth floor by diagonal braces; these columns carry 1,800 pounds to the linear foot.

The wind pressure calculated at the rate of 30 lbs. to the square foot is enormous and is provided for by deep wall girders and knee braces which transfer the strain to the columns and to the foundation. The average cross section of the tower is 75 by 85 feet, the floor s.p.a.ce of the entire building is 1,080,000 square feet or about 25 acres.

The tower of this surpa.s.sing cloud-piercing structure can be seen for many miles from the surrounding country and from the bay it looks like a giant sentinel in white watching the mighty city at its feet and proclaiming the ceaseless activity and progress of the Western World.

CHAPTER VI