The Practical Distiller Part 2

When you have scalded your hogsheads well, put into each, a large handful of oat or rye straw, set it on fire, and stir it till it is in a blaze, then turn the mouth of the hogshead down; the smoke will purify and sweeten the cask. This process should be repeated every other day, especially during summer--it will afford you good working casks, provided your yeast be good, and your hogsheads are well mashed.

There ought always to be in a distillery more vessels than are necessary for immediate use, that they may alternately be exposed to the frost and air one night at least before brought into service, always bearing in mind that the utmost attention to cleanliness is necessary, in order to afford such yield from the grain, or fruit, as may be requisite to compensate for the expense and labor of extracting spirits--and moreover, that the exercise of the finest genius possessed by man is scarcely capable of taking from small grain, all the spirit it contains:.... good materials will not suffice ... the most marked attention is indispensably necessary to yeast; a mind capable of judging of fermentation in all its stages ... a close adherence to the manner of using the ingredients ... preparing them, and the use of sweet vessels, with great industry and a knowledge to apply it at the proper moment, are all necessary to enable the accomplishment of the desired end.

Note ... In scalding your hogshead I would recommend the use of a shovel full of ashes, which will scald more sharply.

SECTION III.

ARTICLE I.

_To Mash Rye in the common mode._

Take four gallons cold water to each hogshead, add one gallon malt, stir it well with your mas.h.i.+ng stick, until the malt is thoroughly wet--when your still boils, put in about sixteen gallons boiling water, then put in one and an half bushels of chopped rye, stirring it effectually, until there is no lumps in it, then cover it close until the still boils, then put in each hogshead, three buckets or twelve gallons boiling water, stirring it well at the same time--cover it close--stir it at intervals until you perceive your rye is scalded enough, which you will know by putting in your mas.h.i.+ng stick, and lifting thereon some of the scalded rye, you will perceive the heart or seed of the rye, like a grain of timothy seed sticking to the stick, and no appearance of mush, when I presume it will be sufficiently scalded--it must then be stirred until the water is cold enough to cool off, or you may add one bucket or four gallons of cold water to each hogshead, to stop the scalding.

I have known this process succeed well with an attentive distiller.

ART. II.

_The best method of distilling Rye._

Take four gallons boiling, and two gallons cold water--put it into a hogshead, then stir in one and a half bushels chopped rye, let it stand five minutes, then add two gallons cold water, and one gallon malt, stir it effectually--let it stand till your still boils, then add sixteen gallons boiling water, stirring it well, or until you break all the lumps--then put into each hogshead, so prepared, one pint coa.r.s.e salt, and one shovel full of hot coals out of your furnace. (The coals and salt have a tendency to absorb all sourness and bad smell, that may be in the hogshead or grain;) if there be a small quant.i.ty of hot ashes in the coals, it is an improvement--stir your hogsheads effectually every fifteen minutes, keeping them close covered until you perceive the grain scalded enough--when you may uncover, if the above sixteen gallons boiling water did not scald it sufficiently, water must be added until scalded enough--as some water will scald quicker than others--it is necessary to mark this attentively, and in mas.h.i.+ng two or three times, it may be correctly ascertained what quant.i.ty of the kind of water used will scald effectually--after taking off the covers, they must be stirred effectually, every fifteen minutes, till you cool off--for which operation, see "_Cooling off._" To those who distill all rye, I recommend this method, as I have found it to answer every kind of water, with one or two exceptions.

Distillers will doubtless make experiments of the various modes recommended and use that which may prove most advantageous and convenient.

ART. III.

_To Mash two thirds Rye and one third Corn in Summer._

This I have found to be the nicest process belonging to distilling--the small proportion of corn, and the large quant.i.ty of scalding water, together with the easy scalding of rye, and the difficulty of scalding corn, makes it no easy matter to exactly hit the scald of both; but as some distillers continue to practice it, (altho' not a good method in my mind, owing to the extreme nice attention necessary in performing it.) In the following receipt I offer the best mode within my knowledge, and which I deem the most beneficial, and in which I shew the process and mode pursued by other distillers.

Take four gallons cold water, put it into a hogshead, then stir half a bushel corn into it, let it stand uncovered thirty minutes, then add sixteen gallons boiling water, stir it well, cover it close for fifteen minutes, then put in your rye and malt and stir it until there be no lumps, then cover it and stir it at intervals until your still boils, then add, eight, twelve, or sixteen gallons boiling water, or such quant.i.ty as you find from experience, to answer best--(but with most water, twelve gallons will be found to answer) stirring it well every fifteen minutes until you perceive it is scalded enough, then uncover and stir it effectually until you cool off; keeping in mind always that the more effectually you stir it, the more whiskey will be yielded. This method I have found to answer best, however, I have known it to do very well, by soaking the corn in the first place, with two gallons warm, and two gallons cold water, instead of the four gallons of cold water, mentioned above--others put in the rye, when all the boiling water is in the hogshead, but I never found it to answer a good purpose, nor indeed did I ever find much profit in distilling rye and corn in this proportion.

ART. IV.

_To distill one half Rye and one half Corn._

This method of distilling equal quant.i.ties of rye and corn, is more in practice, and is much better than to distill unequal proportions, for reason you can scald your corn and rye to a certainty, and the produce is equal if not more, and better whiskey, than all rye. The indian corn is cheaper, and the seed is better than if all rye. I would recommend this, as the smallest quant.i.ty of corn to be mixed with rye for distillation, as being most productive, and profitable. The following receipt I have found to answer all waters--yet there may be places where the distiller cannot follow this receipt exactly, owing to hard or soft water, (as it is generally termed) or hard flint or soft floury corn, that will either scald too much or too little--but this the attentive distiller will soon determine by experience.

Have your hogshead perfectly sweet, put into each, three gallons of cold and three of boiling water, or more or less of each, as you find will answer best--then stir in your corn--fill up your boiler, bring it briskly to a boil--then put to each hogshead twelve gallons boiling water, giving each hogshead one hundred stirs, with your mas.h.i.+ng stick, then cover close, fill up your boiler and keep a good fire under her, to produce a speedy boil; before you add the last water, put into each hogshead one pint of salt, and a shovel full of hot coals and ashes from under your still, stir the salt and coals well, to mix it with your corn, the coal will remove any bad smell which may be in the hogshead--Should you find on trial, that rye don't scald enough, by putting it in after your last water, you may in that case put in your rye before the last water--but this should be ascertained from several experiments. I have found it to answer best to put in the rye after all the water is in the hogshead, especially if you always bring the still briskly to a boil--then on your corn put twelve or sixteen gallons boiling water, (for the last water,) then if you have not already mashed in your rye, put it in with one gallon good malt to each hogshead, carefully stirring it immediately very briskly, for fear of the water loosing its heat, and until the lumps are all broken, which you will discover by looking at your mas.h.i.+ng stick; lumps generally stick to it.

When done stirring, cover the hogshead close for half an hour, then stir it to ascertain whether your grain be sufficiently scalded, and when nearly scalded enough, uncover and stir steady until you have it cool enough to stop scalding; when you see it is scalded enough, and by stirring that the scalding is stopped, uncover your hogsheads, and stir them effectually, every fifteen minutes, until they are fit to cool off--remembering that sweet good yeast, clean sweet hogsheads, with this mode of mas.h.i.+ng carefully, will produce you a good turn out of your grain. The quant.i.ty of corn and rye is generally two stroked half bushels of each, and one gallon malt.

ART. V.

_To Mash one third Rye and two thirds Corn._

This I deem the most profitable mas.h.i.+ng that a distiller can work, and if he can get completely in the way of working corn and rye in this proportion, he will find it the easiest process of mas.h.i.+ng. That corn has as much and as good whiskey as rye or any other grain, cannot be disputed, and the slop or pot ale is much superior to that of any other grain, for feeding or fattening either horned cattle or hogs--one gallon of corn pot ale being esteemed worth three of rye, and cattle will always eat it better--and moreover, corn is always from one to two s.h.i.+llings per bushel cheaper than rye, and in many places much plentier--so that by adopting this method and performing it well, the distiller will find at the close of the year, it has advantages over all other processes and mixtures of rye and corn, yielding more profit, and sustaining the flock better. Hogs fatted on this pot ale, will be found decidedly better than any fatted on the slops of any other kind of mas.h.i.+ng.

_Mash as follows._

Have sweet hogsheads, good yeast and clean water in your boiler; when the water is sharp, warm, or half boiling, put into every hogshead you mean to mash at the same time, six, eight or as many gallons of the half boiling water, as will completely wet one bushel corn meal--add then one bushel chopped corn, stir it with your mas.h.i.+ng stick till your corn is all wet; it is better to put in a less quant.i.ty of water first, and so add as you may find necessary, until completely wet (be careful in all mas.h.i.+ngs, that your mas.h.i.+ng stick be clean), this is called soaking the corn. Then fill up your boiler, bring her quickly to a boil, when effectually boiling, put into every hogshead, twelve gallons boiling water, stirring it well after putting in each bucket, until the lumps are quite broken--cover the hogsheads close, after a complete stirring--fill up your boiler, bring her quickly to boil for the last mas.h.i.+ng--stir the corn in the hogshead every fifteen minutes, till your last water is boiling--put into each hogshead one pint salt, and a shovel full of red hot coals, stirring it well--then put in each hogshead sixteen gallons of boiling water, stir it well--cover it close for twenty-five minutes--then put into each hogshead one half bushel rye meal, and one gallon good chopped malt, stirring it until the lumps are all broken, then cover it close, stir it every half hour, until you perceive it sufficiently scalded--then uncover it and stir it as often as your other business will permit, until ready to cool off.

In this and every other mas.h.i.+ng you must use sweet vessels only and good yeast, or your labor will be in vain; and in all kinds of mas.h.i.+ng you cannot stir too much.

ART. VI.

_To Mash Corn._

This is an unprofitable and unproductive mode of mas.h.i.+ng, but there may be some times when the distiller is out of rye, on account of the mill being stopped, bad roads, bad weather, or some other cause; and to avoid the necessity of feeding raw grain to the hogs or cattle, (presuming every distillery to be depended on for supplying a stock of some kind, and often as a great reliance for a large stock of cattle and hogs,) in cold weather I have found it answer very well, but in warm weather it will not do. Those who may be compelled then from the above causes, or led to it by fancy, may try the following method. To one hogshead, put twelve gallons boiling water, and one and an half bushels corn, stir it well, then when your water boils, add twelve gallons more, (boiling hot,) stir it well, and cover it close, until the still boils the third time, then put in each hogshead, one quart of salt, and sixteen gallons boiling water, stir it effectually, cover it close until you perceive it nearly scalded enough, then put in two, or three gallons cold water, (as you will find to answer best,) and two gallons malt, or more if it can be spared--stir it well, then cover it for half an hour, then uncover and stir it well, until cold enough to cool off.

ART. VII.

_To make four gallons from the bushel._

This is a method of mas.h.i.+ng that I much approve of, and recommend to all whiskey distillers to try it--it is easy in process, and is very little more trouble than the common method, and may be done in every way of mas.h.i.+ng, as well with corn or rye, as also a mixture of each, for eight months in the year; and for the other four is worth the trouble of following. I do not mean to say that the quant.i.ty of four gallons can be made at an average, in every distillery, with every sort of grain, and water, or during every vicissitude of weather, and by every distiller, but this far I will venture to say, that a still house that is kept in complete order, with good water, grain well chopped, good malt, hops, and above all good yeast; together with an apt, careful and industrious distiller, cannot fail to produce at an average for eight months in the year, three and three quarter gallons from the bushel at a moderate calculation. I have known it sometimes produce four and an half gallons to the bushel, for two or three days, and sometimes for as many weeks, when perhaps, the third or fourth day, or week, it would scarcely yield three gallons; a change we must account for, in a change of weather, the water or the neglect or ignorance of the distiller. For instance, we know that four gallons of whiskey is in the bushel of rye or corn--certain, that this quant.i.ty has been made from the bushel; then why not always? Because, is the answer, there is something wrong, sour yeast or hogsheads, neglect of duty in the distiller, change of grain, or change of weather--then of course it is the duty of the distiller to guard against all these causes as near as he can. The following method, if it does not produce in every distillery the quant.i.ty above mentioned, will certainly produce more whiskey from the bushel, than any other mode I have ever known pursued.

Mash your grain in the method that you find will yield you most whiskey--the day before you intend mas.h.i.+ng, have a clean hogshead set in a convenient part of the distillery; when your singling still is run off, take the head off and fill her up with clean water, let her stand half an hour, to let the thick part settle to the bottom, which it will do when settled, dip out with a gallon or pail, and fill the clean hogshead half full, let the hogshead stand until it cools a little, so that when you fill it up with cool water, it will be about milk-warm, then yeast it off with the yeast for making 4 gallons to the bushel, then cover it close, and let it work or ferment until the day following, when you are going to cool off; when the cold water is running into your hogshead of mashed stuff, take the one third of this hogshead to every hogshead, (the above being calculated for three hogsheads) to be mashed every day, stirring the hogsheads well before you yeast them off. This process is simple, and I flatter myself will be found worthy of the trouble.

ART. VIII.

_To know when Grain is scalded enough._

Put your mas.h.i.+ng stick into your hogshead and stir it round two or three times gently, then lift it out and give it a gentle stroke on the edge of your hogshead--if you perceive the batter or musky part fall off your stick, and there remains the heart of the grain on your mas.h.i.+ng stick, like grains of timothy seed, then be a.s.sured that it is sufficiently scalded, if not too much, this hint will suffice to the new beginner, but experience and observation will enable the most correct judgment.

ART. IX.

_Directions for cooling off._

Much observation is necessary to enable the distiller to cool off with judgment--which necessity is increased by the versatility of our climate, the seasons of the year, and the kinds of water used. These circ.u.mstances prevent a strict adherence to any particular or specific mode; I however submit a few observations for the guidance of distillers in this branch.--If in summer you go to cool off with cold spring water, then of course the mashed stuff in your hogsheads must be much warmer, than if you intended cooling off with creek or river water, both of which are generally near milk warm, which is the proper heat for cooling off--In summer a little cooler, and in winter a little warmer.

It will be found that a hogshead of mashed grain will always get warmer, after it begins to work or ferment.

When the mashed stuff in your hogsheads is brought to a certain degree of heat, by stirring, which in summer will feel sharp warm, or so warm, that you can hardly bear your hand in it for any length of time, will do for common water, but for very cold or very warm water to cool off with, the stuff in the hogsheads must be left colder or warmer, as the distiller may think most expedient, or to best suit the cooling off water.

When you think it is time to cool off, have a trough or conveyance to bring the water to your hogsheads ready--let the hogsheads be well stirred, then let the water run into them slowly, stirring them all the time the water is running in, until they are milk warm, then stop the water, and after stirring them perfectly, put in the yeast and stir it until completely incorporated with the mashed stuff, then cover your hogshead until it begins to ferment or work, then uncover it.

ART. X.