The American Reformed Cattle Doctor Part 2

THE BULL.

Mr. Lawson gives us the following description of a good bull. It would be difficult to find one corresponding in all its details to this description; yet it will give the reader an idea of what a good bull ought to be. "The head of the bull should be rather long, and muzzle fine; his eyes lively and prominent; his ears long and thin; his horns white; his neck rising with a gentle curve from the shoulders, and small and fine where it joins the head; his shoulders moderately broad at the top, joining full to his chine and chest backwards, and to the neck-vein forwards; his bosom open; breast broad, and projecting well before his legs; his arms or fore thighs muscular, and tapering to his knees; his legs straight, clean, and very fine boned; his chine and chest so full as to leave no hollows behind the shoulders; the plates strong, to keep his belly from sinking below the level of his breast; his back or loin broad, straight, and flat; his ribs rising one above another, in such a manner that the last rib shall be rather the highest, leaving only a small s.p.a.ce to the hips, the whole forming a round or barrel-like carca.s.s; his hips should be wide placed, round or globular, and a little higher than the back; the quarters (from the hips to the rump) long, and, instead of being square, as recommended by some, they should taper gradually from the hips backwards; rump close to the tail; the tail broad, well haired, and set on so as to be in the same horizontal line with his back."

VALUE OF DIFFERENT BREEDS OF COWS.

Mr. Culley, in speaking of the relative value of long and short horns, says, "The long-horns excel in the thickness and firm texture of the hide, in the length and closeness of the hair, in their beef being finer grained and more mixed and marbled than that of the short-horns, in weighing more in proportion to their size, and in giving richer milk; but they are inferior to the short-horns in giving a less quant.i.ty of milk, in weighing less upon the whole, in affording less fat when killed, in being generally slower feeders, in being coa.r.s.er made, and more leathery or bullish in the under side of the neck. In a few words, the long-horns excel in hide, hair, and quality of beef; the short-horns in the quant.i.ty of beef, fat, and milk. Each breed has long had, and probably may have, their particular advocates; but if I may hazard a conjecture, is it not probable that both kinds may have their particular advantages in different situations? Why not the thick, firm hides, and long, closer set hair, of the one kind be a protection and security against tempestuous winds and heavy fogs and rains, while a regular season and mild climate are more suitable to the const.i.tutions of the short-horns? But it has. .h.i.therto been the misfortune of the short-horned breeders to seek the largest and biggest boned ones for the best, without considering that those are the best that bring the most money for a given quant.i.ty of food. However, the ideas of our short-horned breeders being now more enlarged, and their minds more open to conviction, we may hope in a few years to see great improvements made in that breed of cattle.

"I would recommend to breeders of cattle to find out which breed is the most profitable, and which are best adapted to the different situations, and endeavor to improve that breed to the utmost, rather than try to unite the particular qualities of two or more distinct breeds by crossing, which is a precarious practice, for we generally find the produce inherit the coa.r.s.eness of both breeds, and rarely attain the good properties which the pure distinct breeds individually possess.

"Short-horned cows yield much milk; the long-horned give less, but the cream is more abundant and richer. The same quant.i.ty of milk also yields a greater proportion of cheese. The Polled or Galloway cows are excellent milkers, and their milk is rich. The Suffolk duns are much esteemed for the abundance of their milk, and the excellence of the b.u.t.ter it produces. Ayrs.h.i.+re or Kyloe cows are much esteemed in Scotland; and in England the improved breed of the long-horned cattle is highly prized in many dairy districts. Every judicious selector, however, will always, in making his choice, keep in view not only the different sons and individuals of the animal, but also the nature of the farm on which the cows are to be put, and the sort of manufactured produce he is anxious to bring to market. The best age for a milch cow is betwixt four, or five, and ten. When old, she will give more milk; but it is of an inferior quality, and she is less easily supported."

METHOD OF PREPARING RENNET, AS PRACTISED IN ENGLAND.

Take the calf's maw, or stomach, and having taken out the curd contained therein, wash it clean, and salt it thoroughly, inside and out, leaving a white coat of salt over every part of it. Put it into an earthen jar, or other vessel, and let it stand three or four days; in which time it will have formed the salt and its own natural juice into a pickle. Take it out of the jar, and hang it up for two or three days, to let the pickle drain from it; resalt it; place it again in the jar; cover it tight down with a paper, pierced with a large pin; and let it remain thus till it is wanted for use. In this state it ought to be kept twelve months; it may, however, in case of necessity, be used a few days after it has received the second salting; but it will not be as strong as if kept a longer time. To prepare the rennet for use, take a handful of the leaves of the sweet-brier, the same quant.i.ty of rose and bramble leaves; boil them in a gallon of water, with three or four handfuls of salt, about a quarter of an hour; strain off the liquor, and, having let it stand until perfectly cool, put it into an earthen vessel, and add to it the maw prepared as above. To this add a sound, good lemon, stuck round with about a quarter of an ounce of cloves, which give the rennet an agreeable flavor. The longer the bag remains in the liquor, the stronger, of course, will be the rennet. The amount, therefore, requisite to turn a given quant.i.ty of milk, can only be ascertained by daily use and observation. A sort of average may be something less than a half pint of good rennet to fifty gallons of milk. In Gloucesters.h.i.+re, they employ one third of a pint to coagulate the above quant.i.ty.

MAKING CHEESE.

IT is generally admitted that many dairy farmers pay more attention to the quant.i.ty than the quality of this article of food; now, as cheese is "a surly elf, digesting every thing but itself," (this of course applies to some of the white oak specimens, which, like the Jew's razors, were made to sell,) it is surely a matter of great importance that they should attend more to the quality, especially if it be intended for exportation. There is no doubt but the home consumption of good cheese would soon materially increase, for many thousands of our citizens refuse to eat of the miserable stuff "misnamed cheese."

The English have long been celebrated for the superior quality of their cheese; and we have thought that we cannot do a better service to our dairy farmers than to give, in as few words as possible, the various methods of making the different kinds of cheese, for which we are indebted to Mr. Lawson's work on cattle.

"It is to be observed, in general, that cheese varies in quality, according as it has been made of milk of one meal, or two meals, or of skimmed milk; and that the season of the year, the method of milking, the preparation of the rennet, the mode of coagulation, the breaking and gathering of the curd, the management of the cheese in the press, the method of salting, and the management of the cheese-room, are all objects of the highest importance to the cheese manufacturer; and yet, notwithstanding this, the practice, in most of these respects, is still regulated by little else than mere chance or custom, without the direction of enlightened observation or the aid of well-conducted experiment.

GLOUCESTER CHEESE.

"In Gloucesters.h.i.+re, where the manufacture of cheese is perhaps as well understood as in any part of the world, they make the best cheeses of a single meal of milk; and, when this is done in the best manner, the entire meal of milk is used, without any addition from a former meal.

But it not unfrequently happens that a portion of the milk is reserved and set by to be skimmed for b.u.t.ter; and at the next milking this proportion is added to the new milk, from which an equal quant.i.ty has been taken for a similar purpose. One meal cheeses are princ.i.p.ally made here, and go by the name of _best making_, or simply _one meal cheeses_.

The cheeses are distinguished into _thin_ and _thick_, or _single_ and _double_; the last having usually four to the hundred weight, (112 pounds,) the other about twice that number. The best double Gloucester is always made from new milk.

"The true single Gloucester cheese is thought by many to be the best, in point of flavor, of any we have. The season for making their thin or single cheese is mostly from April to November; but the princ.i.p.al season for the thick or double is confined to May, June, and the early part of July. This is a busy season in the dairy; for at an earlier period the milk is not rich enough, and if the cheese be made later in the summer, they do not acquire sufficient age to be marketable next spring. Very many cheeses, however, can be made even in winter from cows that are well fed. The cows are milked in summer at a very early hour; generally by four o'clock in the morning, before the day becomes hot, and the animals restless and unruly.

CHESTER CHEESE.

"After the milk has been strained, to free it from any impurities, it is conveyed into a cooler placed upon feet like a table, having a spigot at the bottom for drawing off the milk. This, when sufficiently cooled, is drawn off into pans, and the cooler again filled. In so cases, the cooler is large enough to hold a whole meal's milk at once. The rapid cooling thus produced (which, however, is necessary only in hot weather, and during the summer season) is found to be of essential utility in r.e.t.a.r.ding the process of fermentation, and thereby preventing putridity from commencing in the milk before two meals of it can be put together.

Some have thought that the cheese might be improved by cooling the evening's milk still more rapidly, and that this might be effected by repeatedly drawing it off from and returning it into the cistern. When the milk is too cold, a portion of it is warmed over the fire and mixed with the rest.

"The coloring matter, (annatto,) in Ches.h.i.+re, is added by tying up as much of the substance as is thought sufficient in a linen rag, and putting it into a half pint of warm water, to stand over night. The whole of this infusion is, in the morning, mixed with the milk in the cheese-tub, and the rag dipped in the milk and rubbed on the palm of the hand as long as any of the coloring matter can be made to come away.

"The next operation is salting; and this is done, either by laying the cheese, immediately after it comes out of the press, on a clean, fine cloth in the vat, immersed in brine, to remain for several days, turning it once every day at least; or by covering the upper surface of the cheese with salt every time it is turned, and repeating the application for three successive days, taking care to change the cloth twice during the time. In each of these methods, the cheese, after being so treated, is taken out of the vat, placed upon the salting bench, and the whole surface of it carefully rubbed with salt daily for eight or ten days. If it be large, a wooden hoop or a fillet of cloth is employed to prevent renting. The cheese is then washed in warm water or whey, dried with a cloth, and laid on what is called the _drying bench_. It remains there for about a week, and is thence removed to the _keeping house_. In Ches.h.i.+re, it is found that the greatest quant.i.ty of salt used for a cheese of sixty pounds is about three pounds; but the proportion of this retained in the cheese has not been determined.

"When, after salting and drying, the cheeses are deposited in the cheese-room or store-house, they are smeared all over with fresh b.u.t.ter, and placed on shelves fitted to the purpose, or on the floor. During the first ten or fifteen days, smart rubbing is daily employed, and the smearing with b.u.t.ter repeated. As long, however, as they are kept, they should be every day turned; and the usual practice is to rub them three times a week in summer and twice in winter.

STILTON CHEESE.

"Stilton cheese is made by putting the night's cream into the morning's new milk along with the rennet. When the curd has come, it is not broken, as in making other cheese, but taken out whole, and put into a sieve to drain gradually. While this is going on, it is gently pressed, and, having become firm and dry, is put into a vat, and kept on a dry board. These cheeses are exceedingly rich and valuable. They are called the Parmesan of England, and weigh from ten to twelve pounds. The manufacture of them is confined almost exclusively to Leicesters.h.i.+re, though not entirely so.

DUNLOP CHEESE.

"In Scotland, a species of cheese is produced, which has long been known and celebrated under the name of _Dunlop_ cheese. The best cheese is made by such as have a dozen or more cows, and consequently can make a cheese every day; one half of the milk being immediately from the cow, and the other of twelve hours' standing. Their method of making it is simple. They endeavor to have the milk as near as may be to the heat of new milk, when they apply the rennet, and whenever coagulation has taken place, (which is generally in ten or twelve minutes,) they stir the curd gently, and the whey, beginning to separate, is taken off as it gathers, till the curd be pretty solid. When this happens, they put it into a drainer with holes, and apply a weight. As soon as this has had its proper effect, the curd is put back again into the cheese-tub, and, by means of a sort of knife with three or four blades, is cut into very small pieces, salted, and carefully mixed by the hand. It is now placed in the vat, and put under the press. This is commonly a large stone of a cubical shape, from half a ton to a ton in weight, fixed in a frame of wood, and raised and lowered by an iron screw. The cheese is frequently taken out, and the cloth changed; and as soon as it has been ascertained that no more whey remains, it is removed, and placed on a dry board or pine floor. It is turned and rubbed frequently with a hard, coa.r.s.e cloth, to prevent moulding or breeding mites. No coloring matter is used in making Dunlop cheese, except by such as wish to imitate the English cheese.

GREEN CHEESE.

"Green cheese is made by steeping ever night, in a proper quant.i.ty of milk, two parts of sage with one of marigold leaves, and a little parsley, after being bruised, and then mixing the curd of the milk, thus _greened_, as it is called, with the curd of the white milk. These may be mixed irregularly or fancifully, according to the pleasure of the operator. The management in other respects is the same as for common cheese."

Mr. Colman says, "In conversation with one of the largest wholesale cheesemongers and provision-dealers in the country, he suggested that there were two great faults of the American cheese, which somewhat prejudiced its sale in the English market. He is a person in whose character and experience entire confidence may be placed.

"The first fault was the softness of the rind. It often cracked, and the cheese became spoiled from that circ.u.mstance.

"The second fault is the acridness, or peculiar, smart, bitter taste often found in American cheese. He thought this might be due, in part, to some improper preparation or use of the rennet, and, in part, to some kind of feed which the cows found in the pastures.

"The rind may be made of any desired hardness, if the cheese be taken from the press, and allowed to remain in brine, so strong that it will take up no more salt, for four or five hours. There must be great care, however, not to keep it too long in the brine.

"The calf from which the rennet is to be taken should not be allowed to suck on the day on which it is killed. The office of the rennet, or stomach of the calf, is, to supply the gastric juice by which the curdling of the milk is effected. If it has recently performed that office, it will have become, to a degree, exhausted of its strength. Too much rennet should not be applied. Dairymaids, in general, are anxious to have the curd 'come soon,' and so apply an excessive quant.i.ty, to which he thinks much of the acrid taste of the cheese is owing. Only so much should be used as will produce the effect in about fifty minutes.

For the reason above given, the rennet should not, he says, be washed in water when taken from the calf, as it exhausts its strength, but be simply salted.

"When any cream is taken from the milk to be made into b.u.t.ter, the b.u.t.termilk should be returned to the milk of which the cheese is to be made. The greatest care should be taken in separating the whey from the cheese. When the pressing or handling is too severe, the whey that runs from the curd will appear of a white color. This is owing to its carrying off with it the small creamy particles of the cheese, which are, in fact, the richest part of it. After the curd is cut or broken, therefore, and not squeezed with the hand, and all the whey is allowed to separate from it that can be easily removed, the curd should be taken out of the tub with the greatest care, and laid upon a coa.r.s.e cloth attached to a frame like a sieve, and there suffered to drain until it becomes quite dry and mealy, before being put into the press. The object of pressing should be, not to express the whey, but to consolidate the cheese. There should be no aim to make whey b.u.t.ter. All the b.u.t.ter extracted from the whey is so much of the proper richness taken from the cheese."

MAKING b.u.t.tER.

It is a matter of impossibility to make a superior article of b.u.t.ter from the milk of a cow in a diseased state; for if either of the organs of secretion, absorption, digestion, or circulation, be deranged, we cannot expect good blood. The milk being a secretion from the blood, it follows that, in order to have good milk, we must have pure blood. A great deal depends also on the food; certain pastures are more favorable to the production of good milk than others. We know that many vegetables, such as turnips, garlic, dandelions, will impart a disagreeable flavor to the milk. On the other hand, sweet-scented gra.s.ses and boiled food improve the quality, and, generally, increase the quant.i.ty of the milk, provided, however, the digestive organs are in a physiological state.

The processes of making b.u.t.ter are various in different parts of the United States. We are not prepared, from experience, to discuss the relative merits of the different operations of churning; suffice it to say, that the important improvements that have recently been made in the construction of churns promise to be of great advantage to the dairyman.

The method of churning in England is considered to be favorable to the production of good b.u.t.ter. From twelve to twenty hours in summer, and about twice as long in winter, are permitted to elapse before the milk is skimmed, after it has been put into the milk-pans. If, on applying the tip of the finger to the surface, nothing adheres to it, the cream may be properly taken off; and during the hot summer months, this should always be done in the morning, before the dairy becomes warm. The cream should then be deposited in a deep pan, placed in the coolest part of the dairy, or in a cool cellar, where free air is admitted. In hot weather, churning should be performed, if possible, every other day; but if this is not convenient, the cream should be daily s.h.i.+fted into a clean pan, and the churning should never be less frequent than twice a week. This work should be performed in the coolest time of the day, and in the coolest part of the house. Cold water should be applied to the churn, first by filling it with this some time before the cream is poured in, or it may be kept cool by the application of a wet cloth.

Such means are generally necessary, to prevent the too rapid acidification of the cream, and formation of the b.u.t.ter. We are indebted for much of the poor b.u.t.ter, (_cart-grease_ would be a more suitable name,) in which our large cities abound, to want of due care in churning: it should never be done too hastily, but--like "Billy Gray's"

drumming--well done. In winter the churn may be previously heated by first filling it with hot water, the operation to be performed in a moderately warm room.

In churning, a moderate and uninterrupted motion should be kept up during the whole process; for if the motion be too rapid, heat is generated, which will give the b.u.t.ter a rank flavor; and if the motion is relaxed, the b.u.t.ter will go back, as it is termed.